2020 Custom Concessions 26' Mobile Kitchen

This custom-built concession trailer has been meticulously maintained and is in immaculate condition as seen in the photos! At the rear of the trailer is a Southern Pride SPK-500 commercial-grade smoker! This trailer has LED lighting on all sides, a powered Solera awning, Honda Generator, dual propane tanks, an integrated fire suppression system, air conditioning, and an on-demand hot water heater!

For more information, please call Steve at 813-352-1556.

THIS CONCESSION INCLUDES THE FOLLOWING:

SPECIAL WELDING NOTE Reinforced main rails -- Note: extend reinforcement 2'-4' forward of the wheel box/axles & reinforce C/S wall as necessary for 17' roll out awning

1. 8'6" wide x 24' long WorldWide Trailer Manufacturing Mobile Kitchen Trailer, model MK242-8

2. Rear of trailer to be considered a 6' covered open porch for smoker

3. Custom reinforced walk on roof

4. Two - pairs of heavy duty scissor type stabilizer jacks located on front & rear of trailer,

5000 lb static load capacity each

5. Two - custom fabricated steel tread plate propane platforms for 100# LP tanks each

welded to the trailer frame for solid support -- Note: cover top of platforms with ATP

(Aluminum Diamond Tread Plate)

6. Two - custom fabricated upper & lower steel propane tank mounting brackets to secure

LP tanks firmly in place -- brackets are through bolted to front wall for extra support

7. Two - 100 lb propane tanks with a 950,000 BTU 2 stage regulator

8. Extended three piece 'A' frame (5' long tongue) with a heavy duty tongue jack & sand pad

9. 2 5/16" top mount coupler with replaceable locking dog assembly

10. D.O.T. compliant 5/16" safety chains with Clevis safety slip hook & latch

11. 8"x3" rectangular steel tube main rails with equal height 'C' section cross members with

square outriggers & steel side plates - steel cross members on 16" center

12. Two - 7000 LB (14,000 GVWR) 102" wide 10 degree up torsion axles with 12" x 2"

electric brakes, E/Z lube and 8 on 6.5 hubs and drums with weather resistant wiring

13. Four - ST235/85R16 load range 'F' radial tires mounted on an 8 bolt electro deposition

coated silver bullet hole wheel

14. Chassis fully under coated with CPC (Corrosion Preventative Compound)

15. 8' interior height

16. Install 64" long commercial stainless steel NSF APPROVED hood with a high up blast

grease extracting exhaust fan with on/off wall switch -- hood also includes filters, grease

cup & grease tray (Note: there is no space between the top of the hood & ceiling to clean)

17. Custom curbside 3 section TEMPERED GLASS SERVING WINDOW (45" high x 69"

wide), comes with 1 display/picture window & 2 vertical slider windows with screens (16" mesh) for serving customers -- includes custom lift up awning with 2 keyed flush locks for security & gas assist awning rods to raise & secure awning in upright position

18. 36" wide LEFT HAND HINGED lockable pre-framed roadside entry door with screen (16" mesh), flush lock & integrated dead bolt -- Note: start door opening as close to front wall as possible

19. SPECIAL FEATURE Self closing mechanism for entry door

20. 34" exterior grade plywood floor --- CRITICAL: use Wolmanized flooring along

porch only

21. Non-porous and easily cleanable one piece heavy duty commercial grade RTP (Rubber Tread Plate) flooring over exterior grade plywood floor -- Note: cover porch floor with ATP (Aluminum Diamond Tread Plate)

22. Smooth and easily cleanable non-porous white aluminum ceiling liner with no exposed utility lines, piping, conduit or wiring -- bonded for a smooth look (Note: cover porch ceiling with mill finished aluminum)

23. Smooth and easily cleanable non-porous white aluminum interior sidewall liner with no exposed utility lines, piping, conduit or wiring -- bonded for a smooth look

24. Fully insulated sidewalls and ceiling

25. Custom 56" long white laminated interior overhead cabinet with latching cabinet doors

along curbside wall above the sink assembly

26. Custom 12" deep x 78" long white aluminum interior overhead storage tray/shelf along

curbside wall for additional storage space

27. Custom 24" deep x 78" long x 30" high white laminated interior counter along curbside

wall

28. Custom 10" deep x approx. 69" long stainless steel exterior fold down condiment counter

in front of curbside serving window

29. 100 amp, 120/240v service panel/box with a 100 amp main breaker, approximately 20' long shoreline power cord for your electrical connection and through floor cable hatch to run your power cord outside -- CRITICAL: balance panel/legs accordingly

30. SPECIAL FEATURE Interior 120/240v, 50 amp manual transfer receptacle (NEMA 14-50R, 3 pole, 4 wire) with a 5' long power cord with a 4 prong angle male plug (NEMA 14-50P) wired to 'A' frame (tongue) -- NOTE: this power cord is wired to your panel box. Once plugged in to your generator, it will power up the trailer

31. Six - 20 amp, 120v GFI duplex wall receptacles -- Note: use cord drops where applicable

32. One-- 20 amp, 120v exterior weatherproof GFI duplex wall receptacle

33. Three - 4' LED wrap around light fixtures providing 4,000 lumens each - includes

on/off light switch

34. Five - single exterior weatherproof LED floodlights on a GFI breaker -- includes

interior on/off wall switch

35. Custom 24" deep x 80" long x 36" high white laminated enclosure/cabinet with latching

cabinet doors for commercial NSF APPROVED stainless steel 3 compartment "Deli" sink with single faucet & integrated drain boards on each side (bowl size approx. 10x14x10) - includes separate stainless steel hand sink & faucet with divider/splash guard to separate the hand sink from the 3 compartment sink - all sinks will have hot & cold running water under pressure

36. On demand water pump with on/off wall switch

37. 40 gallon fresh water tank (NSF or equal) located under the sink assembly concealed in

custom cabinet enclosure for a clean and professional look - 1/2" hot and cold NSF Pex

water lines

38. SPECIAL FEATURE LP wall mounted instant hot water heater above the sink

assembly

39. Exterior water hook up with back flow preventer to easily fill your water tank or to connect

to city water - includes keyed locking door to prevent vandalism, dust & grime

40. 50 gallon waste water holding tank located under the trailer lower and away from the fresh water tank per regulatory requirements - includes waste vent stack, 1 1/2" PVC

drain lines & back flow preventer per code (Note: waste tank is 15% larger & or greater

than water tank)

41. A dump valve located under the trailer for easy waste removal

42. .030 pre-finished "WHITE" exterior aluminum "BONDED" for a smooth look -- Note:

some screws will be used along seams only to reinforce panels

43. Aluminum teardrop fenderettes over wheel wells

44. 120v, 15,000 BTU roof mounted air conditioner with a 5600 BTU heat strip

45. 14"x14" screened (16" mesh) translucent roof vent with crank -- includes a Maxxair roof

vent cover for rain protection while vent is open

46. S.A.E. color coded 12v electrical system, D.O.T. required exterior lighting package

47. D.O.T. 'A' frame (tongue) mounted battery with breakaway switch

48. 7 way round trailer end connector (7 way RV blade style) - designed to plug in to the tow

vehicle's 7 way round connector

49. Four - chrome ABS hub covers and or trim rings

50. SPECIAL FEATURE Custom 17' motorized roll out awning along curbside (Color:

To Be Determined) -- includes interior switch to retract/extend awning (Note: place

switch where customer can visibly see awning retract/extend)

51. SPECIAL FEATURE Install Honda 10KW gasoline standby generator - includes

custom ATP/aluminum mesh cover to deter theft - Note: mount gen over 'A' frame/tongue as far from front wall as possible & point exhaust pipe away from trailer, LP tank & tongue mounted battery

NOTE: ALL 120v WIRING IS 12 GAUGE WIRE RAN IN MC CABLE. IN ADDITION, ALL OUTLETS ARE GFI RATED FOR COMMERICAL USE.

THIS CONCESSION ALSO INCLUDES THE FOLLOWING EQUIPMENT:

NOTE All cooking & refrigeration equipment is secured and non-movable. Cooking equipment is elevated off floor by legs and or appropriately sized equipment stands

NOTE Fire suppression canister will be wall mounted along roadside wall rear of hood CRITICAL Install an 8" high stainless steel splashguard between the fryer & range w/oven

SPECIAL Custom mounted legs and or platform will be used to elevate prep unit over wheel box -- Note: unit will sit up approx. 6-7" higher than standard height

1. NSF APPROVED 64" long commercial stainless steel hood system with a high up blast grease extracting exhaust fan with an on/off wall switch -- includes fire suppression system

2. NSF APPROVED 35 cu. ft. commercial stainless steel stand up refrigerator

3. NSF APPROVED 19 cu. ft. commercial stainless steel stand up freezer - NOTE: LEFT

HAND HINGE

4. NSF APPROVED 29" commercial stainless steel refrigerated sandwich prep unit with top pans, lid and cutting board

5. NSF APPROVED 35/40 lb commercial stainless steel LP fryer with two baskets

6. NSF APPROVED commercial stainless steel LP 6 burner range with oven

7. NSF APPROVED commercial insulated hot holding cabinet

8. NSF APPROVED 12" long x 30" deep commercial stainless steel work top table with an

adjustable underneath shelf for additional space

9. NSF APPROVED 36" long x 30" deep commercial stainless steel work top table with an

adjustable underneath shelf for additional space

10. ETL approved commercial stainless steel LP gas fired smoker with trailer mount legs,

upgraded stainless steel grates, smoke extractor w/cook & hold feature manufactured by Southern Pride, model SPK-500 (includes commercial NSF APPROVED high up blast grease extracting exhaust fan, roof curb, duct work, double walled vent stack with rain cap and custom ATP exterior trim kit -- mount smoker on porch flush with divider wall)

11. Paper towel holder and soap dispenser next to the hand sink

12. ABC fire extinguisher

13. 64" long x 48" high stainless steel back splash behind the cooking equipment

14. Compliance stickers/decals affixed to trailer --- "GAS SHUT OFF VALVE" & "DANGER

PROPANE NO SMOKING"

ADDITIONAL SERVICES INCLUDED:

1. Run LP service for cooking equipment - includes schedule 40 black iron pipe with main interior and exterior shut off valves, each piece of equipment will have its own dedicated shut off valve as well.